.204 Ruger Totally Explained

Everything about 204 Ruger totally explained

The .204 Ruger is a centerfire rifle cartridge developed in 2004 by Hornady and Ruger. At the time of its introduction, the .204 Ruger was the highest velocity commercially produced cartridge when loaded with factory ammunition, and the only cartridge produced commercially for bullets of .20 inch/5 mm caliber.

Characteristics

The .204 Ruger was developed from the .222 Remington Magnum, which has the largest case capacity in the family that began with the .222 Remington. The .222 Rem. Mag. provides about 10% more case capacity than the most popular member of the family, the NATO 5.56x45 mm (.223 Rem). To make the .204, the .222 Rem. Mag. was necked down to .204 inches (5 mm). Bullets available in .20 caliber range from 26 to 50 grains (1,7 to 3.25g), and although the selection is limited, it's growing as the cartridge gains wider popularity. The Hornady factory load is listed at 4,225 ft/s (1288 m/s) with a bullet. To achieve these velocities, the factory uses a proprietary powder composition specially formulated for the .204 Ruger, and not currently (2007) available to handloaders. Reloading data from Hornady, using commercially available powders, indicates velocity peaking at just under with the bullet. Many AR-15 rifle manufacturers, including Remington, now offer .204 Ruger as an alternative chambering alongside the usual 5.56mm/.223.

Development

The .204 Ruger was the second Ruger-named cartridge produced by a partnership between Ruger and Hornady, the first being the big bore .480 Ruger revolver cartridge, introduced in 2003 for the Super Redhawk. With the backing of a major gunmaker and a major ammunition company, the round was an instant success, with other ammunition makers and firearms makers quickly producing offerings in the new caliber. Ruger's initial offerings included the bolt action Model 77 MKII, and the single shot Ruger #1, and Hornady offered loadings with 32 and bullets.
The .204 Ruger is proving to be a very accurate and efficient cartridge: an early tester reported 1/2 MOA groups at 100 yards (91 m) with the Hornady loads and a Ruger #1 Varmint rifle. This isn't surprising, considering that the first cartridge in the family, the .222 Remington, was a top benchrest shooting cartridge for many years after its introduction.
The .204 Ruger was intended primarily for varmint rifles, which require bullets with flat trajectories but not much mass or kinetic energy. The .20 was "splitting the difference" between the popular .22 varmint rounds such as the .220 Swift and .22-250 Remington, and the tiny .17 caliber rounds such as the .17 Remington and the .17 HMR. The resulting cartridge provides somewhat higher velocities than any of these, giving a maximum point blank range of more than 270 yards (248 m).

Velocity

Ruger's claim to velocity king with the .204 was based on two points. First, that other 4000+ fps cartridges were wildcats, not commercially produced; the 5mm/35 SMc, for example, can reach using a bullet.
Second, the ammunition used to achieve the 4200+ ft/s was only available from Hornady using a special powder not available to the general public . Handloaders typically achieve velocities more in the area of using a bullet.. Note that handloads using a bullet in other commercial cartridges such as the .220 Swift and .223 WSSM also achieve similar velocities to the .204 Ruger. The advantage of the .20 caliber .204 is that it achieves these velocities using less powder, less recoil, and less heat than the heavier cartridges. The 204 Ruger has a maximum range of approximately 500 yards
One of the down-sides to firing bullets at such velocities is short barrel life. Generally speaking, extremely fast bullets tend to wear out a barrel significantly sooner than slower ones. The high pressures, temperatures, and friction can quickly wear away portions of the throat and rifling. This erosion results in deteriorating accuracy. The amount of erosion and time it takes to negatively affect accuracy is based on things like temperature, bore-size, velocity, etc. This effect is common to all small arms cartridges that approach or exceed muzzle velocities of, including the .17 Remington, .220 Swift, and .22-250 Remington.

Further Information

Get more info on '204 Ruger'.

External Link Exchanges

Do you know how hard it is to get a link from a large encyclopaedia? Well we're different and will prove it. To get a link from us just add the following HTML to your site on a relevant page:

<a href="http://_204_ruger.totallyexplained.com">.204 Ruger Totally Explained</a>

Then simply click through this link from your web page. Our crawlers will verify your link, extract the title of your web page and instantly add a link back to it. If you like you can remove the words Totally Explained and embed the link in article text.
As long as your link remains in place, we'll keep our link to you right here. Please play fair - our crawlers are watching. Your site must be closely related to this one's topic. Any kind of spamming, dubious practises or removing the link will result in your link from us being dropped and, potentially, your whole site being banned.